BWQYS - ULTRA-LITE 3-35

Export as PDF
Product Identification

Product ID:ULTRA-LITE 3-35
MSDS Date:12/23/1992
FSC:6850
NIIN:00-050-0659
MSDS Number: BWQYS

Responsible Party
CRC CHEMICALS U.S.A./CRC INDUSTRIES, INC.
885 LOUIS DRIVE
WARMINSTER, PA 18974-2820
US

Emergency Phone: 215-674-4300

Info Phone: 215-674-4300

Preparer: JON BROWN

Cage: 10136

Contractor
CRC INDUSTRIES, INC.
WARMINSTER, PA 18974-2820 US

Telephone: 215-674-4300/800-424-9300

Cage: 10136

Ingredients

PETROLEUM DISTILLATE (SOLVENT NAPHTHA (PETROLEUM) MEDIUM

CAS: 64742-88-7

Fraction By Weight: 86.4%

OSHA PEL 5 MG/M3 (OIL MIST)

ACGIH TLV: 5 MG/M3 (OIL MIST)


OXYGENATED PETROLEUM FRACTION

Fraction By Weight: 9.6%


CARBON DIOXIDE (PROPELLANT)

CAS: 124-38-9

RTECS: FF6400000

Fraction By Weight: 4%

OSHA PEL 10000PPM/30000STEL

ACGIH TLV: 5000PPM/30000STEL;92

Hazards

Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: CONTACT MAY CAUSE EYE
IRRITATION. SKIN CONTACT MAY CAUSE DRYNESS. INHALATION MAY CAUSE
BREATHING PROBLEMS; MAY CAUSE HEADACHES, NAUSEA, DIZZINESS.
CHRONIC: PROLONGED EXPOSURE MAY CAUSE DERMATIT IS.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUEPECTED CARCINOGEN.
Effects of Overexposure:EYES-IRRITATION. SKIN-DRYNESS, DERMATITIS.
INHALED-NAUSEA, HEADACHES, DIZZINESS. INGESTED-NONE SPECIFIED BY
MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid

First Aid:INHALATION-REMOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION
IF NEEDED. GET MEDICAL ATTENTION. EYE-FLUSH WITH WATER FOR 15
MINUTES. GET MEDICAL ATTENTION. SKIN-WASH WITH SOAP & WATER. REMOVE
CONTAMINAT ED CLOTHING. INGESTION-DO NOT INDUCE VOMITING! CALL A
PHYSICIAN.

Fire Fighting

Flash Point Method:TOC
Flash Point:160F,71C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER. DLA-HMIS: WEAR
SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE GEAR. COOL
FIRE EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:AEROSOL CONTAINERS MAY EXPLODE WHEN
HEATED ABOVE 120F.

Accidental Release

Spill Release Procedures:VENTILATE AREA. ABSORB WITH INERT MATERIAL AND
PLACE IN A CLOSED CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling

Handling and Storage Precautions:STORE IN A COOL, DRY, WELL-VENTILATED
AREA.
Other Precautions:AEROSOL CANCES MAY EXPLODE IF HEATED ABOVE 120F.
VAPORS ARE HEAVIER THAN AIR AND WILL COLLECT IN LOW AREAS. OSHA
SHORT TERM EXPOSURE LIMIT (STEL) FOR OIL IS 5 MG/M3.

Exposure Controls

Respiratory Protection:NONE SPECIFIED BY MANUFACTURER. DLA-HMIS: IF
ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE OR AN EMERGENCY
OCCURS; WEAR AN MSHA/NIOSH APPROVED RESPIRATOR OR AN AIR-SUPPLIED
RESPIRATOR OR SCBA, AS REQUI RED. USE IAW 29 CFR 1910.134.
Ventilation:NONE SPECIFIED BY MFR. DLA-HMIS: USE ADEQUATE MECHANICAL
VENTILATION OR LOCAL EXHAUST TO MAINTAIN EXPOSURE BELOW TLV.
Protective Gloves:NITRILE.
Eye Protection:SAFETY GLASSES W/SIDE SHIELDS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health

Chemical Properties

HCC:V2
Boiling Pt:=196.1C, 385.F
Vapor Pres:<1
Vapor Density:>4.5
Spec Gravity:0.8043
Evaporation Rate & Reference:<0.01 (TOLUENE=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER LIQUID; PETROLEUM DISTILLATE ODOR.
Percent Volatiles by Volume:>90

Stability

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE
(FIRE).

Disposal

Waste Disposal Methods:ALL USED AND UNUSED MATERIAL SHOULD BE DISPOSED
OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS. NOTE:
THIS PRODUCT CONTAINS NO CHEMICALS THAT ARE SUBJECT TO REPORTING
UNDER SECTION 313 OF SARA TITLE III.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.